Product ID:8400, MAC'S RUBBERIZED UNDERCOAT
MSDS Date:05/31/1989
FSC:8030
NIIN:00-546-8621
MSDS Number: CCLRW

VALVOLINE OIL CO SUBSIDIARY OF ASHLAND OIL INC.

200 E MAIN ST
LEXINGTON, KY 40512
US

Emergency Phone: 800-ASHLAND/800-274-5263

Info Phone: 606-264-7000/7616;FAX 601-429-0537

Cage: 72527

VALVOLINE OIL CO

14000 LEXINGTON, KY 40512 US

Telephone: 606-357-7206 / 800-274-5263

Cage: 72527

STODDARD SOLVENT

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 55-70%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9495

ISOBUTANE

CAS: 75-28-5

RTECS: TZ4300000

Fraction By Weight: 1-10%

PROPANE

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 1-10%

OSHA PEL 1000 PPM

ACGIH TLV: ASPHYXIANT; 9495

METHYL ALCOHOL (METHANOL) (SARA 313) (CERCLA)

CAS: 67-56-1

RTECS: PC1400000

Fraction By Weight: 1-5%

OSHA PEL S, 200 PPM

ACGIH TLV: S,200PPM/250STEL; 95

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LD50 LC50 Mixture:PRODUCT'S LD50 (ORAL RAT) WAS NOT STATED
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE IRRITATION, REDNESS,
TEARING, BLURRED VISION. PROLONGED &/OR REPEATED SKIN CONTACT MAY
CAUSE IRRITATION, DEFATTING, DERMATITIS. BREATHING:MAY CAUSE NASAL
& RESPIRATORY IRRITATION, CNS E FFECTS. SWALLOWNING:MAY CAUSE G/I
IRRITATION, NAUSEA, VOMITING, DIARRHEA. ASPIRATON INTO LUNGS MAY BE
FATAL.
Explanation of Carcinogenicity:MANUFACTURER GAVE NO INFORMATION ABOUT
CARCINOGENICITY. HMIS FOUND NO LISTING & DOES NOT EXPECT IT TO BE
CARCINOGENIC.
Effects of Overexposure:MFR GAVE NO INFORMATION OF MSDS. SEE HEALTH
HAZARDS.
Medical Cond Aggravated by Exposure:GET IMMEDIATE MEDICAL ATTENTION.

First Aid:IF IRRITATION PERSISTS OR IS SEVERE, GET MEDICAL ATTENTION.
EYE:FLUSH W/WATER FOR 15 MIN. SKIN:WASH W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE. INHALED:REMOVE FROM
EXPOSURE. A ID OR RESTORE BREATHING AS NEEDED. INGESTED:DO NOT
INDUCE VOMITING. KEEP VICTIM WARM & QUIET & GET IMMEDIATE MEDICAL
ATTENTION. ASPIRATION OF PRODUCT INTO LUNGS DURING VOMITING MAY BE
FATAL.

Flash Point:20.0F,-6.7C
Lower Limits:1.6
Extinguishing Media:REGULAR FOAM, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:WATER MAY BE USED TO KEEP EXPOSED CONTAINERS
COOL. WEAR SELF-CONTAINED BREATHING APPARATUS W/FULL FACEPIECE
OPERATED IN POSITIVE PRESSURE MODE FOR FIGHTING FIRE
Unusual Fire/Explosion Hazard:NEVER USE A TORCH ON OR NEAR DRUM (EVEN
EMPTY) BECAUSE IT CAN EXPLODE. BOND OR GROUND 5 GAL OR LARGER
CONTAINERS WHEN TRANSFERRING LIQUID.

Spill Release Procedures:SMALL SPILL:ELIMINATE SOURCES OF IGNITION.
ALLOW TO EVAPORATE. ABSORB LIQUID W/ABSORBENT MATERIAL. LARGE
SPILL:ELIMINATE SOURCES OF IGNITION. ALLOW TO EVAPORATE. EVACUATE
UNPROTECTED PERSONNEL. SOAK UP SPILL W/ABSORBENT MATERIAL.
Neutralizing Agent:MFR GAVE NO INFORMATION OF MSDS.

Handling and Storage Precautions:"EMPTY" CONTAINERS RETAIN RESIDUE &
CAN IGNITE EXPLOSIVELY. DO NOT CUT, DRILL, OR WELD ON OR NEAR FULL
OR EMPTY CONTAINERS.

Respiratory Protection:IF EXPOSURE LIMITS OF PRODUCT IS EXCEEDED WEAR A
NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR IN THE ABSENCE OF
PROPER ENVIRONMENTRAL CONTROL. OSHA REGULATIONS PERMIT OTHER
RESPIRATORS UNDER SPECIFIED CONDITIONS.
Ventilation:USE MECHANICAL (GENERAL) VENTILATION & LOCAL EXHAUST TO
KEEP EXPOSURE Protective Gloves:RESISTANT, NITRILE RUBBER
Eye Protection:SPLASH GOGGLES; COMPLY W/OSHA REGUALTION
Other Protective Equipment:IMPERVIOUS CLOTHING & BOOTS TO PREVENT
PROLONGED &/OR REPEATED SKIN CONTACT.
Work Hygienic Practices:MFR GAVE NO INFORMATION OF MSDS.
Supplemental Safety and Health
NONE

HCC:V3
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:-45F,-43C
Vapor Pres:9257 MM
Vapor Density:>1.0
Spec Gravity:UNAVAILABLE
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:AEROSOL LIQUID
Percent Volatiles by Volume:70-85

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, TEMPERATURES OVER 100F(38C).
Stability Condition to Avoid:MFR GAVE NO INFORMATION OF MSDS.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
VARRIOUS HYDROCARBONS
Conditions to Avoid Polymerization:CANNOT OCCUR

Waste Disposal Methods:SMALL SPILL:ALLOW VOLITILES TO EVAPORATE IN
HOOD. DISPOSE OF REMAINDER I/A/W APPLICABLE REGULATIONS. LARGE
SPILL:VENTILATE AREA OF SPILL. ALLOW MATERIAL TO EVAPORATE. PUT
CONTAMINATED ABSORBENT IN A LANDFILL I/A/W FEDERAL, STATE & LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.